DAVEY-logo

DAVEY PHP16 Supercell Pressure Tanks

DAVEY-PHP16-Supercell-Pressure-Tanks - product

LAPATAIGA: MAXIMUM WORKING PRESSURE RATING FOR :-

  • SUPERCELL Suffix ‘P’ is 1000kPa (145 psi)
  • SUPERCELL Suffix ‘PHP16’ is 1600kPa (232 psi)
  • SUPERCELL Suffix ‘HP25’ is 2500kPa (363 psi)

LAPATAIGA: Wherever it is possible that the pump system pressure may reach or exceed the tank pressure rating under any circumstance (e.g. pressure switch incorrectly set), it is strongly recommended that the system is protected by a suitable pressure relief valve set at or below the maximum tank pressure rating. Failure to install a pressure relief valve may result in tank failure causing property damage or serious personal injury.

FAATUATUA: To prevent personal injury, ensure all water pressure is released from the pressure system prior to work being performed. Ensure pumps are disconnected and/or electrically isolated.
Fa'amolemole tu'u atu nei fa'atonuga ile fa'afoeina o lenei masini.

FAITAU FAATONUGA UMA AE LE'I FA'ATAU LOU SUPERCELL TANK FOU
O fa'atonuga nei ua saunia e fa'amasani ai oe ile auala sa'o e fa'apipi'i ma fa'agaioi ai lau Supercell Tank. Matou te uunaʻia oe e suʻesuʻe ma le faaeteete lenei lomiga ma mulimuli i ana fautuaga. A tula'i mai fa'alavelave fa'apipi'i po'o mana'omia fo'i se isi fautuaga, e tatau ona e fa'afeso'ota'i le Dealer lea na e fa'atau mai ai le masini po'o lou Ofisa Fa'atau oloa a Davey vai lata ane.

FAAMANATU:

  • All models (Supercell Suffix ‘P’, ‘PHP16’ and ‘HP25’) will accept water up to 90ºC maximum.
  • Be sure to protect the Supercell tank and all associated pumps and piping from freezing temperatures.

FA'ATA'U E TATAU ONA FEAGAI MA TULAFONO PLUMBING LOCAL LOCAL PLUMBING CODES PE'A E FA'AITAI AI.

Tank Pre-charge

For correct operation pressure tanks should be pre-charged as follows:

  •  For pressure switch controlled pumps with cut-in pressure set at 140 kPa (20 psi), pre-charge the tank to 15kPa (2 psi) below the cut in pressure.
  • For tanks installed with a pressure switch controlled pump with a differential pressure set up to 200 kPa (30 psi), the pre-charge should be set to 15 kPa (2 psi) below the cut-in pressure.
  • For tanks installed with a pump controlled by a pressure switch with a pressure differential greater than 200 kPa (30 psi), electronic controls or variable speed controls, the pre-charge should be set to 65% of the cut-out or maximum system pressure.
  • For tanks installed on mains’ pressure, the tank pre-charge should be set equal to the mains’ pressure. For mains’ pressure exceeding 6 bar (88 psi), a suitable pressure regulator should be installed.
  • For hot water expansion, pre-charge should be set as per the mains pressure details above.

For your convenience, all suffix ‘P’ pressure tanks have been factory set at 200kPa (29 psi) and suffix ‘PHP16’ and ‘HP25’ models which have 400kPa (58psi).

FA'AALIGA: Aua ne'i soona fa'ae'e le tane ma fa'aoga le ea i le na'o le vevela!

Fa'apipi'i

FAAMANATU: Ina ia aloese mai le faaleagaina o le vai i meatotino mai paipa ta'e, tafega o feso'ota'iga, pa'u masaesa/su'e pamu, ma isi mea, pamu ma mea faigaluega fa'atasi (e aofia ai le Supercell Pressure Tank) e tatau ona fa'apipi'i i luga o se nofoaga e fa'amama lelei po'o totonu o se pa puipui ua fausia lelei ma fata alavai.

Bottom Entry Models
Connect the tank vertically in the outlet piping of the water pump being used. Thread seal tape is necessary.
Aua le soona fa'amalama!

Base Mounted Models
These units have the inlet positioned on the bottom of the tank. Ensure that any fittings used firmly retain the pipe or hose connected. Thread tape should be used on all threads.
E tatau ona tuu le tane i luga o se faavae mautu. Afai e ono tupu le tetete i tafatafa o le tane e tatau ona faʻaeʻe i luga o se mauga maufe.
Ina ia mautinoa e maua e lau tane lona ola aupito maualuga e tatau ona faʻapipiʻi i se tulaga ufiufi ma mago. E le tatau ona fa'atagaina le tane e mimilo i so'o se mea malo e si'omia, e pei o puipui, ma isi.

  • Installation Inside Buildings: To cater for possible plumbing or tank failure, the installation must include an enclosure that will capture any water spraying from the tank and direct it into a properly constructed drain tray.
  • Fa'aaliga: A fa'apipi'i se Supercell Tank ma/po'o se pamu fa'atasi i totonu o se fale, e TATAU ona faia se alauni mo le so'ona maualuga.
  • Fa'aaliga: Ina ia mafai ona fa'atinoina le tausiga masani ole Supercell Pressure Tank E TATAU ona faigofie ona maua e le tagata fa'aaoga po'o le pule ile fale.

Su'eina ma Toe Fa'atumu le Totogi o le Ea

Supercell ‘P’, ‘PHP16’ and ‘HP25’ Pressure Tanks do not require regular checks under normal operating conditions. However, if air charge adjustment is required then follow the following procedures:

  1. Remove the pressure tank completely from pump installation, ensuring to isolate the pressure tank and release the water pressure from the tank beforehand. OR
    Tu'u uma le mamafa o le vai mai le tane vai e ala i le tapeina o le pamu i le nofoaga o le eletise, ma tatala le kapoti paipa. Mo tane sapalai i luga a'e o le eleele e tatau ona tapuni le alatoto faitotoa i le va o tane sapalai ma le pamu.
    FA'AALIGA: Ina ia puipuia le manu'a o le tagata lava ia, ia mautinoa o lo'o alu uma le mamafa o le vai mai le faiga fa'amalosi a'o le'i faia le galuega.
    Tuu le paipa e tatala i le taimi e toe faatumu ai le ea.
  2. When all water pressure has been released from the system, check air pressure at air valve on top of pressure tank. The pre-charge pressure reading should be as detailed on page 3 of this document.
  3. If necessary, replenish air charge to the correct pressure indicated. Ensure that a tap in outlet piping of pump is open during replenishment of air pre-charge.

FAAMANATU: I le taimi o le toe faʻaleleia o le ea e tatau ona asiasia fafo le tane. So'o se fa'ailoga o le tafe mai le tane e ono ta'u mai ai le mana'omia o se suiga vave.

Siaki Vaitaimi
Flushing: Depending on the quality of the pumped water, from time to time your tank may require flushing to remove settled fines such as mud or sand. If sand or mud is allowed to stay in the tank it will accelerate wear on the internal lining and shorten your tanks life. Safely disconnect the tank from the water supply, discharge all air from the tank and flush the tank several times with clean water. Once the flushing water is clean, reconnect the tank and recharge the air as per above.
Asiasiga i fafo: O se tane i le tulaga lelei o le a le tafe, ae a oʻo i le taimi ona o le faʻaleagaina e ala i le gaogao o le tagofiaina, aʻafiaga poʻo le paʻu ma/poʻo le eleelea i totonu o le vai e mafai ona paʻu ma/poʻo le paʻu le atigi tane. Afai e lia le tane pe fa'aalia ni fa'ailoga o le faaletonu e tatau ona motusia vave le tane ma sui.

LAPATAIGA: Do not use tank if it leaks or shows signs of corrosion or damage.

Operational Difficulties & Trouble Shooting

NOTE: Loss of air charge is the most overwhelming cause of difficulties with Supercell Pressure Tanks. Partial or complete loss of air charge will cause any of the following problems:-

  • Rapid pump cycling (i.e. pump stops and starts frequently during operation).
  •  Decreased draw-off capacity.

I le isi itu, o ia lava fa'afitauli e mafai ona mafua mai i se diaphragm ua tu'i po'o le tafe e pei ona fa'aalia i le tafe mai o le vai mai le alavai o le ea pe a fa'avaivaia le 'autu o le valve (e masani lava pe a siaki le tane muamua.
Supercell Suffix ‘P’, ‘PHP16’ and ‘HP25’ models have a diaphragm which is captive and is non-serviceable. In the event of diaphragm failure the whole tank must be replaced.

Fa'ailoga Mafuaaga Fofoga
Pump Cycling

(Pump stops and starts frequently while operating)
  1.  Punctured diaphragm (check that water escapes from air valve when depressed)
  2.   Incorrectly set pressure switch
  3. Incorrect pressure tank pre-charge
  1.     Sui Tank.
  2.   Reset pressure switch to manufacturers recommendations
  3. Adjust tank pre-charge to 15kPa (2psi) below cut-in
E tu le pamu ma amata pe a tapuni uma paipa
  1.  Leaking tap or pipework on suction and/or discharge side
  1.   Isolate suction pipework, if pump continues to stop and start, check for leaks on discharge. If pump stops and does not restart, problem is likely to be leaking check valve on suction side of pump system.
Water flow from open tap stops then starts when first opened
  1.    Tank pre-charge set too high or too low
  2.   Pressure switch cut-in set too low
  1. Adjust tank pre-charge to 15kPa (2psi) below cut-in
  2.  Adjust pressure switch cut-in
O le tane e le mafai ona taofiofia le ea a'o le'i totogi
  1. Faulty air valve
  2. Diaphragm tu'ia
  1. Replace air valve core
Nominal Tusi Tape Malosiaga in Liters                                                                                                                                              Mumu.
Tane Fa'ata'ita'iga Tane Malosiaga (lita) MaxPressure Rating (kPa) Va'aiga Suiga o le Oomi kPa (psi) Diamita (mm) Maualuluga (mm) Ulufale
150-250(22-36) 150-300(22-44) 200-400(29-58) 250-400(36-58) 250-500(36-73) 300-600(44-88) 500-800(73-116) 500-1000(73-145) 700-1200(101-174) 1000-1600(145-232) 1600-2000(232-290) 2000-2500(290-363) Tele (BSP)
Supercell 8P 8 1000 2.2 3.0 3.2 2.4 3.3 3.4 2.7 3.5 N/A N/A N/A N/A 203 317 1”M
Supercell 18P 18 1000 5.0 6.7 7.2 5.4 7.4 7.6 6.0 8.0 N/A N/A N/A N/A 279 368 1”M
Supercell 40P 40 1000 10.7 14.1 15.2 11.5 16.0 16.5 13.3 17.7 N/A N/A N/A N/A 318 481 1”M
Supercell 60P 60 1000 16.1 21.2 22.8 17.2 23.9 24.8 20.0 26.6 N/A N/A N/A N/A 388 626 1”F
Supercell 100P 100 1000 28.6 37.5 40.0 30.0 41.7 42.9 33.3 45.5 N/A N/A N/A N/A 430 804 1”F
Supercell 200G 200 800 57.1 75.0 80.0 60.0 83.3 85.7 66.7 N/A N/A N/A N/A N/A 533 1033 11/4”F
Supercell 18PHP16 18 1600 3.0 6.8 7.2 5.4 7.5 7.7 8.2 6.9 6.4 N/A N/A N/A 279 367 1”M
Supercell 80PHP16 80 1600 21.5 28.2 30.4 23.0 31.9 28.7 26.7 35.5 30.2 27.9 N/A N/A 388 790 1”F
Supercell 24HP25 24 2500 6.3 8.3 9.0 6.3 9.4 10.3 8.0 10.5 9.1 8.4 4.5 4.6 260 445 1”M
Supercell 100HP25 100 2500 26.3 34.5 37.3 28.3 39.3 41.3 33.3 43.9 37.7 34.8 18.9 19.1 460 935 1”M

Fa'aaliga: Afai e sili atu i luga ole laiga ole suiga ole mamafa, ole Acceptance Factor e tatau ona fuafua ma e tatau ona itiiti ifo i le 0.5. Afai o le tau o le AF e sili atu i le 0.5 ona tatau lea ona faʻaititia le eseesega e ala i le faʻateleina o le tipi ma le muaʻi totogi poʻo le faʻaitiitia o le mamafa tipi.
AF = (cut-out kPa – pre-charge kPa)
(tipi kPa + 100)

FA'ATA'U FA'AMATALAGA

FAAMANATU:
Isolation valves, ball valves and gauges will improve serviceability.

DAVEY-PHP16-Supercell-Pressure-Tanks - (1)

FA'ATA'IGA FA'AVAE FA'AVAE FA'ATAU

FAAMANATU
Isolation valves, ball valves and gauges will improve serviceability.

DAVEY-PHP16-Supercell-Pressure-Tanks - (2)

Davey Fa'amaonia

Davey Water Products Pty Ltd (Davey) fa'amaonia oloa uma e fa'atau atu o le a (i lalo o le fa'aoga masani ma le tautua) e leai ni fa'aletonu i meafaitino ma galuega mo le itiiti ifo i le tasi (1) tausaga mai le aso na fa'atau muamua ai e le tagata fa'atau e pei ona fa'ailogaina i luga. le pili, mo vaitaimi fa'amaonia fa'apitoa mo oloa uma a Davey asiasi daveywater.com.
O lenei tusi fa'amaonia e le aofia ai le ofuina masani ma le masaesae pe fa'aoga i se oloa e iai:

  • ua noatia i le fa'aoga sese, le amana'ia, fa'atamala, fa'aleagaina po'o fa'alavelave
  • sa fa'aogaina, fa'agaioia pe tausia e ese mai le tusa ai ma fa'atonuga a Davey
  • e le'i fa'apipi'iina e tusa ai ma Fa'atonuga Fa'apipi'i po'o ni tagata faigaluega fa'apitoa
  • ua suia pe suia mai uluai faʻamatalaga poʻo soʻo se auala e leʻi faʻatagaina e Davey
  • na toe fa'aleleia pe na faia e se isi nai lo Davey po'o ana fa'atau fa'atagaina
  • na a'afia i tulaga fa'aletonu e pei ole le sa'o voltage sapalai, uila po'o le maualuga voltagu tui, poʻo mea faʻaleagaina mai gaioiga eletise, cavitation, oneone, pala, masima poʻo vai abrasive,

O le warranty Davey e le aofia ai le suia o soʻo se oloa faʻaaogaina poʻo faʻaletonu i oloa ma vaega na tuʻuina atu ia Davey e isi vaega (peitaʻi o Davey o le a tuʻuina atu fesoasoani talafeagai e maua ai le manuia o soʻo se isi vaega faʻamaonia).
Ina ia faia se tagi fa'amaonia:

  •  Afai o le oloa e masalomia ua faaletonu, taofi le faʻaaogaina ma faʻafesoʻotaʻi le nofoaga muamua na faʻatau ai. I le isi itu, telefoni Davey Customer Service pe lafo se tusi ia Davey e tusa ai ma faʻamatalaga faʻafesoʻotaʻi o loʻo i lalo
  • Tuuina atu faʻamaoniga poʻo faʻamaoniga o le aso o le faʻatau muamua
  • Afai e talosagaina, toe faafoi le oloa ma / poʻo le tuʻuina atu o nisi faʻamatalaga e faʻatatau i le tagi. O le toe fa'afo'i atu o le oloa i le nofoaga na fa'atau mai ai o lau tau ma o lau matafaioi lea.
  • O le tagi fa'amaonia o le a iloiloina e Davey i luga o le fa'avae o latou iloa o oloa ma fa'amasinoga talafeagai ma o le a talia pe afai:
    • ua maua se faaletonu talafeagai
    • o le tagi fa'amaonia e faia i totonu o le vaitaimi talafeagai; ma
    • e leai se tasi o aiaiga e le aofia o lo'o lisi atu i luga e fa'aoga
  • O le a logoina le tagata fa'atau i le fa'ai'uga tusitusia ma afai e maua e le aoga e tatau i le tagata fa'atau ona fa'atulaga le aoina o le oloa ia latou tupe fa'aalu pe fa'atagaina lona lafoaia.

If the claim is found to be valid Davey will, at its option, repair or replace the product free of charge. The Davey warranty is in addition to rights provided by local consumer law. You are entitled to a replacement or refund for a major failure and compensation for any other reasonably foreseeable loss or damage. You are also entitled to have the goods repaired or replaced if the goods fail to be of acceptable quality and the failure does not amount to a major failure. For any internet connected products the consumer is responsible for ensuring a stable internet connection. In the event of a network failure the consumer will need to address the concern with the service provider. Use of an App is not a substitute for the User’s own vigilance in ensuring the product is working to expectation.

Use of a Smart Product App is at the User’s own risk. To the fullest extent permitted by law Davey disclaims any warranties regarding the accuracy, completeness or reliability of App data. Davey is not responsible for any direct or indirect loss, damage or costs to the User arising from its reliance on internet connectivity. The User indemnifies Davey against any claims or legal actions from them or others relying on internet connectivity or App data may bring in this regard. Products presented for repair may be replaced by refurbished products of the same type rather than being repaired. Refurbished parts may be used to repair the products. The repair of your products may result in the loss of any user-generated data. Please ensure that you have made a copy of any data saved on your products.
I le tulaga atoatoa e fa'atagaina e le tulafono po'o le tulafono, e le noatia Davey mo so'o se gau o tupe mama po'o so'o se fa'ai'uga, fa'aletonu pe fa'apitoa gau, fa'aleagaina po'o se manu'a so'o se ituaiga so'o se mea e tula'i mai sa'o pe leai fo'i mai oloa a Davey. O lenei tapula'a e le fa'atatau i so'o se noataga a Davey mo le le usita'ia o se fa'amaoniga a tagata fa'atau e fa'atatau i lau oloa Davey i lalo o tulafono fa'alotoifale ma e le a'afia ai so'o se aia tatau po'o se fofo e mafai ona avanoa mo oe i lalo o tulafono fa'alotoifale.
Mo se lisi atoa o Davey Dealers asiasi i matou webnofoaga (daveywater.com) pe valaau:

  • Davey Water Products Pty Ltd
  • Sui o le GUD Group
  • ABN 18 066 327 517
  • daveywater.com

AUSETALIA

Ulu Ofisa

  • 6 Vaitulotoview Drive, Scoresby, Ausetalia 3179
  • Ph: 1300 232 839
  • Fax: 1300 369 119
  • imeli: sales@davey.com.au

NIU SILA
7 Rockridge Avenue, Penrose, Aukilani 1061

Europa
7 rue Eugène Hénaff 69200
Vénissieux, Farani

AMERIKA MATU

Sasa'e Tutotonu

Davey ose fa'ailoga fa'ailoga a Davey Water Products Pty Ltd. © Davey Water Products Pty Ltd 2023.

FAQ

  • Q: Ou te manaʻomia e siaki e le aunoa le tau o le ea o le tane?
    A: Under normal conditions, regular checks are not required. However, adjustments may be needed occasionally.

Pepa / Punaoa

DAVEY PHP16 Supercell Pressure Tanks [pdf] Tusi Taiala
PHP16, HP25, PHP16 Supercell Pressure Tanks, PHP16, Supercell Tanks Pressure, Tanks Pressure, Tanks

Fa'asinomaga

Tuu se faamatalaga

E le fa'asalalauina lau tuatusi imeli. Fa'ailogaina fanua mana'omia *